Ultrasonic monitoring of stress and cracks of the 1/3 scale mock-up of nuclear reactor concrete containment structure

Qi Xue (1) , Éric Larose (1) , Ludovic Moreau (1) , Romain Thery (2, 1) , Odile Abraham (2, 3) , Jean-Marie Henault (4)

1 ISTerre - Institut des Sciences de la Terre
2 Université Gustave Eiffel
3 GERS-GeoEND - Laboratoire Géophysique et évaluation non destructive
4 EDF - EDF

To evaluate the stress level and damage of a reinforced concrete containment wall (similar to those used in nuclear power plants) and its reaction to pressure variations, we implemented successive ultrasonic experiments on the exterior surface of the containment wall in the gusset area for three consecutive years (2017, 2018 and 2019). During each experiment, the pressure inside the containment wall increased gradually from 0 MPa to 0.43 MPa and then decreased back to 0 Mpa. From the analysis of the ultrasonic coda waves obtained in the multiple scattering regime (80-220 kHz), we performed Coda Wave Interferometry to calculate the apparent velocity changes in the structure (denoted by dV /V a) and Coda Wave Decorrelation (DC) measurements to produce 3D cartographies of stress and crack distribution. From three source-receiver pairs, located at the top, middle and bottom of the experimental region, we observe that coda waves dilate, shrink and remain almost unchanged, respectively. This corresponds to the decreasing, increasing and invariant pressure inside the concrete. The comparison of three years' results demonstrates that the variation of dV /V a and DC under the same pressure test increases through the years, which indicates the progressive deterioration and aging of the concrete. From a large collection of source-receiver pairs at different times, the spatial-temporal variations of dV /V a and DC are then used to produce a map of the structural velocity and scattering changes, respectively. We observe a decreasing velocity on the top part and an increasing in the middle one, which is in line with the dV /V a analysis. The reconstructed scattering changes (or structural changes) highlight the active region during the inflationdeflation procedure, corresponding to the opening and closing (and sometimes the development) of cracks. The larger magnitude in 2019 than in 2017 indicates the increasing damage in the concrete.

Mots clés: Coda wave interferometry; diffuse ultrasound; cracks in concrete; velocity change; stretching and correlation

Domaines: Génie civil

Qi Xue, Éric Larose, Ludovic Moreau, Romain Thery, Odile Abraham, et al.. Ultrasonic monitoring of stress and cracks of the 1/3 scale mock-up of nuclear reactor concrete containment structure. Structural Health Monitoring, 2021, ⟨10.1177/14759217211034729⟩. ⟨hal-03313112⟩