Evidence of reverse and intermediate size segregations in dry granular flows down a rough incline

Nathalie Thomas (1) , Umberto D 'Ortona (2)

1 IUSTI - Institut universitaire des systèmes thermiques industriels
2 M2P2 - Laboratoire de Mécanique, Modélisation et Procédés Propres

In a dry granular flow, size segregation had been shown to behave differently for a mixture containing a few large particles with a size ratio above 5 (N. Thomas, Phys. Rev. E 62, 961 (2000)). For moderately large size ratios, large particles migrate to an intermediate depth in the bed: this is called ``intermediate segregation". For the largest size ratios, large particles migrate down to the bottom of the flow: this is called ``reverse segregation" - in contrast with surface segregation. As the reversal and intermediate depth values depend on the fraction of particles, this numerical study mainly uses one single large tracer. Small fractions of large beads are also computed showing the link between single tracer behavior and collective segregation process. For each device (half-filled rotating tumbler and rough plane), two (2D) and three (3D) dimensional cases are distinguished. In the tumbler, the trajectories of a large tracer show that it reaches a constant depth during the flowing phase. For large size ratios, this depth is intermediate. A progressive sinking of the depth is obtained when the size ratio is increased. The largest size ratios correspond to tracers being at the bottom of the flowing layer. All 3D simulation results are in quantitative agreement with the experimental surface, intermediate, and reverse segregation results. In the flow down a rough incline, a large tracer reaches an equilibrium depth during flow. For large size ratios, the depth is inside the bed, at an intermediate position, and for the largest size ratios, this depth is reverse, located near the bottom. Results are slightly different for a thin or a thick flow. For 3D thick flows, the reversal between surface and bottom positions occurs within a short range of size ratios: no tracer stabilizes near half-height and two reachable intermediate depth layers exist, below the surface and above the bottom reverse layer. For 3D thin flows, all intermediate depths are reachable by a tracer, depending on the size ratio. The numerical study of larger fractions of tracers (5 or 10%) shows the three segregation patterns (surface, intermediate, reverse) corresponding to the three types of equilibrium depth. The reversal is smoother than for a single tracer, and happens around the size ratio 4.5, in good agreement with experiments.

Mots clés: incline; granular flow; size segregation; reverse segregation; tumbler; drum

Domaines: Matière Molle [cond-mat.soft]

Nathalie Thomas, Umberto D 'Ortona. Evidence of reverse and intermediate size segregations in dry granular flows down a rough incline. Physical Review E , 2018, 97 (2), ⟨10.1103/PhysRevE.97.022903⟩. ⟨hal-01418018v2⟩